燃气蒸汽锅炉如何保养?
    2018-7-20 16:19:56  文章来源:http://www.jnlzsb.com

    燃气蒸汽锅炉如果长期不用的话,需要进行保养。天气渐暖长期不用的保养方法:有干法和湿法两种。
    Gas steam boilers need maintenance if they are not used for a long time. There are two ways to keep the weather warm and dry for a long time: dry and wet.
                                山东燃气锅炉 

    A、干法保养
    A, dry maintenance
    锅炉停炉后放去炉水,将内部污垢彻底清除,冲洗干净,在膛炉内用微火烘干(注意不要用大火),然后将直径10-30毫米的块状的生石灰分盘装好,放置在锅筒内,不使生石灰与金属接触。生石灰的重量,以锅筒容积每立方米8公斤计算,然后将所有的手孔管道阀门关闭,每三个月检查一次,如生石灰碎成粉状,即需更换,锅炉重新运行时应将生石灰合盘取出。
    After the boiler is stopped, the furnace is removed and the internal dirt is cleaned thoroughly, rinsed and dried in the hearth furnace (attention should not be made with fire), and then the lump of 10-30 millimeters of lump in diameter is packed and placed in the pot, so that the lime is not exposed to the metal. The weight of the lime is calculated by 8 kilograms per cubic meter of cylinder volume, and then all the hand - hole pipe valves are closed every three months. If the lime is crushed to powder, it needs to be replaced, and the lime should be taken out of the boiler when the boiler is reoperated.
    B、湿法保养
    B and wet maintenance
    停炉后放出炉水,将内部污垢彻底清除,冲洗干净,重新注入已处理的水至全满,将炉水加热到100℃,让水中的气体排出炉外,然后关闭所有阀门,气候寒冷的地方可不使用湿法保养,以免炉水结冰损坏炉胆。
    After stopping the furnace, the furnace water is released, the internal fouling is cleared completely, rinse clean, reinjected into the processed water to full, heat the furnace water to 100 degrees C, let the gas out of the water out of the furnace, then close all the valves, and the cold weather can not use wet maintenance, so as to avoid the ice damage to the furnace gallbladder.

    上文由山东燃气锅炉厂家提供,想要了解更多的精彩内容,请关注我们的网站:http://www.jnlzsb.com